PDA

View Full Version : Need Help no dealer . 28 HP Kaw on 2008 Exmark...


MJB
08-24-2011, 12:24 AM
Normally Kawasaki engines are known for lugging power. I mean I could normally engage the blades at low throttle no problem. Now it sputters and loses power. After I run it for 10 minutes mowing it gets worse to where I can not even mow with it. I've drained the fuel tanks, fuel filter, spark plugs, and just had the carb cleaned and reinstalled. It ran great for 10 minutes of mowing then it started losing power again. Seems to be worse after it warms up to running temps. Even after I disengage the blades it sputters until it reaches full rpm's. Clears up under no load at full throttle, but sputters bad when you go from an idle to full rpm's.

Could I have a coil getting weak? What else should I check?

Restrorob
08-24-2011, 07:00 AM
I suggest checking/adjusting the valves, That cost nothing. Then do a running coil test, Set the engine speed to where it runs worst then pull each plug wire one at a time with rubber handled pliers. If the engine shuts down when a wire is removed the coil on the other side isn't firing.....