Register free!

The Green Industry's Resource Center



Reply
 
Thread Tools   Display Modes
  #1  
Old 11-30-2012, 10:32 PM
mowisme mowisme is online now
LawnSite Senior Member
 
Join Date: Apr 2007
Location: Fitchburg, Wisconsin
Posts: 823
fighting a battery draw on Honda GX620?

I disconnected the ground off battery and ran a test light from it to motor block- no light came on so this mean no direct short or am I testing wrong? I have two batterys to try- both were up to 12+ volts for over several months. It I put one onto the Honda GX620..few days its dead. I have positive wire going from Battery to the 20a rectifier/reg, and I have another positive wire going from battery to a ignition switch..that when is in the 'on' position it lets the 12v leave the switch and travel to a 'momental' toggle switch to run a small 12v motor whenever I hold the switch to one side or other. releasing it cuts the power. by turning ignition switch 'off' no power is even fed to that switch. My question: could the constant power to the regulator/rectifier draw the battery down? (this is wired from factory to reg/rect)
Reply With Quote
  #2  
Old 11-30-2012, 11:03 PM
Restrorob's Avatar
Restrorob Restrorob is offline
LawnSite Fanatic
 
Join Date: Apr 2005
Location: Show'n my truck off !
Posts: 10,778
Gene,

I seen the post where you were told to put a light on the ground cable, I've never tested that way. Remove the pos cable and put your test light lead clip on the cable then the point to the battery post, If you have a short/draw the light will come on.

If it does, Unplug the regulator and see if it goes out. Yes a regulator can short and cause a draw and still put out voltage as normal when running.

If it is shorted, You can run a jumper wire from your main switch to the regulator so it's only powered when running/switch is on. This would save cost of replacement for a while......
__________________
Quote:
Originally Posted by piston slapper View Post
You never learn anything until you admit you don't know it all...
Quote:
Originally Posted by MannsLawnService View Post
some times the man in my mirror isn't so smart...
"Why go out preserved when you can go out beat up, worn out, sliding in sideways screaming, Holy Sh!t What A Ride" !!!
Reply With Quote
  #3  
Old 12-01-2012, 12:08 AM
mowisme mowisme is online now
LawnSite Senior Member
 
Join Date: Apr 2007
Location: Fitchburg, Wisconsin
Posts: 823
Thanks RR..

Thanks Rob- I'll do them test tomorrow. Gene
Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump





Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2014, Jelsoft Enterprises Ltd.
Copyright ©1998 - 2012, LawnSite.comô - Moose River Media
All times are GMT -4. The time now is 10:49 AM.

Page generated in 0.05477 seconds with 9 queries