1. Missed the live Ask the Expert event?
    Not to worry. Check out the archived thread of the Q&A with Ken Hutcheson, President of U.S. Lawns, and the LawnSite community on the Franchising Forum.

    Dismiss Notice

23hp Kawasaki stalls when PTO engaged

Discussion in 'Mechanic and Repair' started by andymiller, Aug 16, 2010.

  1. andymiller

    andymiller LawnSite Member
    Posts: 1

    I have a 23hp Kawasaki on a SCAG Tiger Cub. When I mow for more that 30 min, when engine heats up, the engine stalls out. It will start right back up, but a few minutes later it stalls again. This only happens when the PTO is engaged. It is also blowing the 20amp fuse. I have replaced the fuel filter, cleaned both fuel tanks, replaced spark plugs, replaced electric PTO clutch, replaced PTO switch, replaced fuel pump, and installed a new battery. I have even put a "jumper" on the safety switch under the seat, just in case the switch was going bad. I assume it is an electrical problem but not sure. Does anyone have a suggestion as to what it could be? I have had it in the shop 4 times now with no success.
    Thanks in advance.
     
  2. DT Lawn Care

    DT Lawn Care LawnSite Senior Member
    Posts: 850

    Sounds like you checked everything but the ignition coils. That would be my next step
     

Share This Page