1. Missed the live Ask the Expert event?
    Catch up on the conversation about fertilization strategies for success with the experts at Koch Turf & Ornamental in the Fertilizer Application forum.

    Dismiss Notice

Battery won't recharge on SST16 John Deere Mower.

Discussion in 'Mechanic and Repair' started by pw64, Oct 7, 2009.

  1. pw64

    pw64 LawnSite Member
    Messages: 3

    I took the battery out and had it recharged a couple of times......after using awhile, it dies again, but won't recharge in mower.
    I pulled the negative cable off, and it shut the engine off, which makes me know that I have a problem on the mower and not the battery. Any suggestions on how to solve this problem?
    Help will be much appreciated! Thanks!
  2. ccecilm

    ccecilm LawnSite Member
    Messages: 48

  3. fly-4-fun

    fly-4-fun LawnSite Member
    Messages: 0

    If you have a volt=ohm meter, you can check the voltage of the battery with the engine off. Then start the engine, and recheck voltage. If voltage hasn't increased to about 13.5 to 14 volts, charging system needs to be checked. You can check the the stator voltage by unplugging the connector that comes from the engine that connects to the regulator. Set you meter to AC volts, start engine and run at full speed, voltage should be about 20 volts AC. If it's not, then the stator is bad. If you have 20+ volts AC then stator is ok. Voltage regulator-rectifier can be checked by connecting the stator back up and running engine full speed and checking voltage at the orange wire and the yellow wires. You should have 13+ volts DC at each wire, if you do not, replace regulator-rectifier.

Share This Page