1. Can’t make it to the GIE+EXPO 2017?
    LawnSite brings the trade show floor to your fingertips with our new GIE+EXPO 2017 Sneak Peek video series debuting now in the Lawn Mowing forum.

    Dismiss Notice

Trailer light bulbs

Discussion in 'Lawn Mowing' started by peteloare, Sep 19, 2002.

  1. peteloare

    peteloare LawnSite Member
    Messages: 59

    Im very tired of replacing the bulbs in my trailer. The elements break every other day due to vibration. Any ideas?
  2. LED's ............... Anyone know where to find any?
  3. ScotLawn

    ScotLawn LawnSite Senior Member
    Messages: 309

    you either have a tire out of balance or a bent rim that is causing the vibration. I have never had the problem before.

  4. Piedmont Lawn

    Piedmont Lawn LawnSite Member
    Messages: 178

  5. Runner

    Runner LawnSite Fanatic
    Messages: 13,497

    It sounds like you may have a single axled trailer. They tend to have alot of "bounce". Tandems are quite a bit smoother. If you do or don't have a tandem, check all your mounts, and make sure they are good and tight. You may even want to go as far as mounting a rubber grommet between each mount to help cushion the shake. Also stay away from them when around the trailer. I see people all the time kicking them, using them for steps, etc. Keep the insides greased up, and make sure your holding flanges are good and snug inside. Other than that, you may have to try a higher quality light. I've pretty much alway used the preverbial Petersons, and have had good luck with those, although I don't believe that THOSE are exactly the finest quality lights in the world either, if you know what I mean. I hope this helps! Incidentally, I know some people down there. Are you familiar with a company called K&D Roadgrading? He is a contractor that keeps up several private roads downthere. He makes it big down there.
  6. NBLL

    NBLL LawnSite Member
    Messages: 77

    What are the part numbers of your bulbs? There bulbs available for over the road trucks that are heavy duty versions of the same bulbs that come out in cars. LEDs are a good idea too, if you want to make the initial investment and they don't get knocked off regularly.:)
  7. TLS

    TLS LawnSite Fanatic
    Messages: 7,943

    The lights that come STOCK on landscape trailers are CRAPOLA!!!

    In 1995, I rewired and relamped my entire trailer. You wouldn't believe where they had wires running on that thing! I was always replacing bulbs on those cheapo's.

    When I relamped, I used all BETTS INDUSTRIES fixtures http://www.bettsind.com/en/lighting/default.asp

    They are VERY good quality, and beleive it or not, I haven't replaced one bulb yet since! NOT ONE! I used high quality wire, and ran it in wire loom. Used epoxy filled wirenuts, and silicone anywhere the wire loom passed through the frame. I dont know if Betts sells outright, but my Dad is a distributer and installs them on trucks all the time. They have some nice new LED's but with the performance that I'm getting out of my standard bulb fixtures, I doubt that I'll switch this trailer over.

    Good Luck, hope this helps.
  8. greenman

    greenman LawnSite Addict
    Messages: 1,405

    LED lights can be found at truck stops
  9. jeffyr

    jeffyr LawnSite Senior Member
    Messages: 876

    A search on Yahoo for "Trailer lights" and "Truck Lights" turns up many hits on LED distributors........Nice, but pricy little buggers !

  10. sdwally

    sdwally LawnSite Senior Member
    Messages: 386

    We have gotten tried of the same problem. We are slow converting to leds lamps. First we tried using what Napa carries at $75 with a lifetime warranty. Sent a lot back for free replacement. Belive our problem with them is that the operators drop there end gate the last few feet to the ground. Lights mounted on gates.
    Switch to different brand that starts with a "G", sorry brain fart this morning. These leds are resin filled and cost about $35 plus the connector, a few dollars.
    We also prefer the leds because they are brighter and get your attention. We also have relocated our lamps from the lower outside corners of the trailer to about half way up the ramps on the outside to be more visible.
    We get most of our electrical supplies from a place called the Lighthouse which carries only automotive lighting parts and supplies.

Share This Page